2006 Mitsubishi Lancer Evolution IX (Evo 9) Service and Repair Service Manual

This 2006 Mitsubishi Lancer Evolution IX (Evo 9) Workshop Manual Covers

• Complete factory workshop procedures
• Scheduled servicing and maintenance
• Engine overhaul and repairs
• Turbocharger servicing
• Manual transmission servicing
• ACD and Super AYC repairs
• Electrical diagnostics
• Factory wiring diagrams
• Body repairs
• Diagnostic troubleshooting
• Technical specifications
• Component testing

Engine Options

Turbocharged Petrol

• 2.0L 4G63 MIVEC DOHC 16-Valve Intercooled Turbocharged Inline-4 (CT9A)

Transmission Options

• 5-speed manual transmission (RS/GSR)
• 6-speed manual transmission (MR)

Engine and Drivetrain Repair Coverage

• Complete engine overhaul procedures
• Engine removal and installation
• Cylinder head servicing
• Timing belt replacement
• Balance shaft servicing
• MIVEC valve timing diagnostics
• Turbocharger overhaul
• Wastegate inspection
• Intercooler servicing
• Charge-air system diagnostics
• Fuel injection servicing
• Ignition system diagnostics
• Electronic throttle diagnostics
• Cooling system repairs
• Lubrication system servicing
• Intake and exhaust system repairs
• EVAP system diagnostics
• Emissions control servicing
• Manual transmission overhaul
• Clutch replacement procedures
• Transfer case servicing
• Front differential servicing
• Rear differential servicing
• Driveshaft servicing
• CV joint replacement

Turbocharged Performance Technologies

• MIVEC variable valve timing diagnostics
• Turbocharger diagnostics
• Boost pressure testing
• Boost control solenoid testing
• Intercooler inspection
• Charge-air leak testing
• Wastegate adjustment
• Knock sensor diagnostics
• Fuel pressure testing
• High-performance ignition system diagnostics

AWD Technologies

• Active Centre Differential (ACD) diagnostics
• Super Active Yaw Control (Super AYC) servicing
• Transfer case servicing
• Front limited-slip differential repairs
• Rear differential servicing
• ACD hydraulic system diagnostics
• AYC pump diagnostics
• Wheel speed sensor testing
• Yaw rate sensor calibration
• AWD control system troubleshooting

Chassis, Steering and Suspension

• Front MacPherson strut suspension
• Rear multi-link suspension
• Bilstein suspension servicing (MR)
• Steering rack overhaul
• Hydraulic power steering diagnostics
• Wheel alignment specifications
• Wheel bearing replacement
• Ball joint servicing
• Control arm replacement
• Stabiliser bar servicing

Braking Systems

• Brembo performance brake system servicing
• ABS diagnostics
• Electronic Brakeforce Distribution (EBD)
• Brake booster servicing
• Brake master cylinder overhaul
• Brake caliper rebuilding
• Parking brake adjustment
• Wheel speed sensor diagnostics
• ABS hydraulic unit servicing

Electrical Systems and Wiring

• Complete factory wiring diagrams
• Engine ECU diagnostics
• CAN Bus communication diagnostics
• Charging system testing
• Starting system servicing
• Alternator overhaul
• Starter motor servicing
• Battery testing
• Lighting system wiring
• Instrument cluster diagnostics
• Power window diagnostics
• Central locking repairs
• Power mirror wiring
• Audio system wiring
• Immobiliser diagnostics
• Relay testing
• Connector pin-outs
• Ground point locations
• Electrical circuit testing

Air Conditioning and HVAC

• Air conditioning diagnostics
• Climate control servicing
• Compressor replacement
• Condenser servicing
• Evaporator repairs
• Refrigerant system testing
• HVAC control diagnostics
• Heater core servicing
• Blower motor replacement

Body, Interior and Restraint Systems

• SRS airbag diagnostics
• Seat belt pretensioner servicing
• Dashboard removal
• Door trim removal
• Window regulator servicing
• Rear wing servicing
• Exterior lighting repairs
• Interior trim servicing
• Door lock servicing
• Exterior mirror repairs

Diagnostics and Troubleshooting

• Factory MUT diagnostic procedures
• Engine performance diagnostics
• Turbocharger diagnostics
• Boost pressure troubleshooting
• Fuel system diagnostics
• MIVEC diagnostics
• ACD diagnostics
• Super AYC diagnostics
• ABS troubleshooting
• SRS fault diagnosis
• CAN Bus diagnostics
• Electrical circuit testing
• Sensor testing
• Actuator testing
• Factory diagnostic flowcharts

Common Error Codes Covered

Engine Codes

• P0101 — Mass Air Flow Sensor Range/Performance
• P0113 — Intake Air Temperature Circuit High Input
• P0171 — System Too Lean (Bank 1)
• P0234 — Engine Overboost Condition
• P0299 — Turbocharger Underboost Condition
• P0300 — Random/Multiple Cylinder Misfire Detected
• P0301 — Cylinder 1 Misfire Detected
• P0302 — Cylinder 2 Misfire Detected
• P0303 — Cylinder 3 Misfire Detected
• P0304 — Cylinder 4 Misfire Detected
• P0335 — Crankshaft Position Sensor Circuit Malfunction
• P0340 — Camshaft Position Sensor Circuit Malfunction
• P0420 — Catalyst System Efficiency Below Threshold
• P0442 — EVAP System Small Leak Detected
• P0507 — Idle Speed Higher Than Expected
• P0606 — ECM/PCM Processor Fault

Drivetrain and Chassis Codes

• C1015 — Front Right Wheel Speed Sensor Circuit
• C1020 — Front Left Wheel Speed Sensor Circuit
• C1210 — Brake Pressure Sensor Fault
• C2116 — ABS Pump Motor Circuit Fault
• U0100 — Lost Communication With Engine Control Module
• U0121 — Lost Communication With ABS Control Module
• U1100 — CAN Communication Line Error

Body Control Codes

• B1206 — Driver Door Lock Circuit Malfunction
• B1213 — Passenger Door Lock Circuit Malfunction
• B2404 — Blower Motor Circuit Malfunction

Plus many additional Mitsubishi-specific diagnostic codes.

Fuse Box Diagram

• Engine compartment fuse box layout
• Passenger compartment fuse box layout
• Fuse identification chart
• Relay locations
• Fuse amperage ratings
• Protected circuit identification
• Power distribution diagrams

Wiring Diagrams

• Engine management wiring
• Turbocharger control wiring
• Fuel injection wiring
• Ignition system wiring
• ABS wiring
• ACD wiring
• Super AYC wiring
• SRS wiring
• Air conditioning wiring
• Lighting circuits
• Instrument cluster wiring
• Power windows
• Central locking
• Audio system wiring
• CAN Bus network diagrams
• Connector views
• Ground point diagrams

Serpentine Belt and Timing System Information

• Timing belt replacement procedures
• Timing belt tensioner servicing
• Balance shaft timing procedures
• Camshaft timing specifications
• MIVEC timing procedures
• Timing mark illustrations
• Accessory drive belt routing
• Drive belt tension specifications
• Timing component inspection

Torque Specifications

• Cylinder head bolt torque
• Main bearing cap torque
• Connecting rod bolt torque
• Crankshaft pulley torque
• Camshaft sprocket torque
• Flywheel torque
• Clutch assembly torque
• Wheel nut torque
• Brake caliper torque
• Suspension fastener torque
• Differential fastener torque
• Engine mount torque
• Spark plug torque

Maintenance and Service Information

• Factory maintenance schedules
• Engine oil specifications
• Manual transmission oil specifications
• Transfer case oil specifications
• Rear differential oil specifications
• Coolant specifications
• Brake fluid specifications
• Power steering fluid specifications
• Spark plug replacement intervals
• Air filter servicing
• Cabin air filter replacement
• Timing belt replacement intervals
• Cooling system maintenance
• Brake inspection procedures
• Tyre rotation procedures
• Battery maintenance

Who Is This Manual For?

• New Zealand automotive workshops
• Independent repair garages
• Performance vehicle specialists
• Automotive technicians
• Auto electricians
• Diagnostic specialists
• Motorsport teams
• DIY owners
• Automotive training institutions