2017 Nissan Juke Service and Repair Manual

This 2017 Nissan Juke Service & Repair Manual Covers

• Complete factory workshop procedures
• Scheduled servicing and maintenance
• Engine overhaul and repair
• Turbocharger servicing where fitted
• Manual and CVT transmission servicing
• AWD system servicing where fitted
• Electrical diagnostics
• Factory wiring diagrams
• Body repairs
• Diagnostic troubleshooting
• Technical specifications
• Component testing

Engine Options

Petrol

• 1.6L HR16DE DOHC 16-Valve Inline-4
• 1.6L MR16DDT DOHC DIG-T Turbocharged Inline-4

Transmission Options

• 5-speed manual transmission
• 6-speed manual transmission
• Xtronic CVT

Engine and Drivetrain Repair Coverage

• Engine overhaul procedures
• Engine removal and installation
• Cylinder head servicing
• Timing chain inspection and replacement
• Variable valve timing diagnostics
• Fuel injection diagnostics
• Direct injection diagnostics where fitted
• Electronic throttle control diagnostics
• Ignition system servicing
• Cooling system repairs
• Engine lubrication servicing
• Intake and exhaust system repairs
• EVAP system diagnostics
• Emissions control servicing
• Turbocharger diagnostics
• Intercooler servicing
• Charge-air system inspection
• Manual transmission servicing
• CVT diagnostics and servicing
• Clutch replacement
• Driveshaft servicing
• CV joint replacement
• Transfer case servicing where fitted
• Rear differential servicing where fitted

Turbocharged and Petrol Technologies

• DIG-T turbocharger diagnostics
• Boost pressure testing
• Charge-air system inspection
• Intercooler inspection
• Wastegate control diagnostics
• Fuel pressure testing
• Direct injection diagnostics
• Variable valve timing diagnostics
• Electronic throttle diagnostics
• Knock sensor diagnostics

4WD and AWD Technologies

• ALL MODE 4×4-i diagnostics where fitted
• Intelligent AWD control diagnostics
• Transfer case inspection
• Rear differential servicing
• AWD control module diagnostics
• Wheel speed sensor testing
• Steering angle sensor diagnostics
• Yaw rate sensor diagnostics

Chassis, Steering and Suspension

• Front MacPherson strut suspension
• Rear torsion beam suspension
• Rear multi-link suspension where fitted
• Electric power steering diagnostics
• Steering column servicing
• Steering rack inspection
• Wheel alignment procedures
• Wheel bearing replacement
• Control arm servicing
• Ball joint inspection
• Stabiliser bar servicing
• Shock absorber replacement

Braking Systems

• Hydraulic brake system servicing
• Front disc brake servicing
• Rear disc/drum brake servicing
• Anti-lock Braking System (ABS) diagnostics
• Electronic Brakeforce Distribution (EBD)
• Brake Assist diagnostics
• Vehicle Dynamic Control (VDC) diagnostics
• Brake master cylinder servicing
• Brake booster inspection
• Parking brake adjustment
• Wheel speed sensor diagnostics

Electrical Systems and Wiring

• Complete factory wiring diagrams
• Engine control module diagnostics
• Transmission control module diagnostics
• AWD control system wiring where fitted
• CAN Bus communication diagnostics
• BCM diagnostics
• Intelligent Power Distribution Module (IPDM) diagnostics
• Charging system testing
• Starting system diagnostics
• Alternator servicing
• Starter motor servicing
• Battery testing
• Lighting system wiring
• Instrument cluster diagnostics
• Power window diagnostics
• Central locking diagnostics
• Intelligent Key system diagnostics
• Immobiliser diagnostics
• Audio and navigation system wiring
• Relay testing
• Fuse testing
• Connector pin-outs
• Ground point locations

Air Conditioning and HVAC

• Manual and automatic climate control diagnostics
• Air conditioning compressor servicing
• Condenser servicing
• Evaporator servicing
• Refrigerant circuit testing
• HVAC control diagnostics
• Blower motor servicing
• Heater core replacement
• Air mix door diagnostics
• Cabin air filter servicing

Body, Interior and Restraint Systems

• SRS airbag diagnostics
• Seat belt pretensioner servicing
• Occupant classification system diagnostics
• Dashboard removal
• Door trim removal
• Window regulator servicing
• Tailgate servicing
• Exterior lighting repairs
• Interior trim servicing
• Door lock servicing
• Exterior mirror repairs
• Central locking diagnostics

Diagnostics and Troubleshooting

• Factory CONSULT diagnostic procedures
• Engine performance diagnostics
• Turbocharger diagnostics
• Fuel system diagnostics
• CVT diagnostics
• Manual transmission diagnostics
• AWD diagnostics where fitted
• ABS troubleshooting
• VDC diagnostics
• SRS fault diagnosis
• BCM diagnostics
• IPDM diagnostics
• CAN Bus diagnostics
• Electrical circuit testing
• Sensor testing
• Actuator testing
• Factory diagnostic flowcharts

Common Error Codes Covered

Engine Codes

• P0101 — Mass or Volume Air Flow Circuit Range/Performance
• P0113 — Intake Air Temperature Sensor 1 Circuit High
• P0128 — Coolant Thermostat Temperature Below Regulating Temperature
• P0171 — System Too Lean
• P0300 — Random/Multiple Cylinder Misfire Detected
• P0301 — Cylinder 1 Misfire Detected
• P0302 — Cylinder 2 Misfire Detected
• P0303 — Cylinder 3 Misfire Detected
• P0304 — Cylinder 4 Misfire Detected
• P0335 — Crankshaft Position Sensor A Circuit
• P0340 — Camshaft Position Sensor A Circuit
• P0420 — Catalyst System Efficiency Below Threshold
• P0442 — EVAP System Small Leak Detected
• P0455 — EVAP System Large Leak Detected
• P0507 — Idle Control System RPM Higher Than Expected
• P0606 — ECM/PCM Processor Fault

Transmission Codes

• P0700 — Transmission Control System Malfunction
• P0715 — Input/Turbine Speed Sensor A Circuit
• P0720 — Output Speed Sensor Circuit
• P0730 — Incorrect Gear Ratio
• P0746 — Pressure Control Solenoid A Performance or Stuck Off
• P0841 — Transmission Fluid Pressure Sensor/Switch A Circuit Range/Performance

ABS and Chassis Codes

• C1101 — ABS Sensor System Fault
• C1103 — Front Right Wheel Speed Sensor Circuit
• C1104 — Front Left Wheel Speed Sensor Circuit
• C1105 — Rear Right Wheel Speed Sensor Circuit
• C1106 — Rear Left Wheel Speed Sensor Circuit
• C1110 — ABS Actuator and Electric Unit Fault

Network Communication Codes

• U1000 — CAN Communication Circuit
• U1001 — CAN Communication Circuit
• U0100 — Lost Communication With ECM/PCM
• U0101 — Lost Communication With Transmission Control Module
• U0121 — Lost Communication With Anti-Lock Brake System Module

Body Control Codes

• B2190 — Steering Lock Unit Malfunction
• B2191 — Key ID Discord
• B2618 — BCM Circuit Fault

Plus many other codes included in the manual.

Fuse Box Diagram

• Engine compartment fuse box layout
• Passenger compartment fuse box layout
• Intelligent Power Distribution Module (IPDM) layout
• Fuse identification chart
• Relay locations
• Fuse amperage ratings
• Protected circuit identification
• Power distribution circuits

Wiring Diagrams

• Engine management wiring
• Fuel injection wiring
• Turbocharger control wiring
• Manual transmission wiring
• CVT wiring
• ALL MODE 4×4-i wiring where fitted
• ABS and VDC wiring
• SRS wiring
• BCM wiring
• IPDM wiring
• Air conditioning wiring
• Lighting circuits
• Instrument cluster wiring
• Intelligent Key system wiring
• Central locking wiring
• Power window wiring
• Audio and navigation wiring
• CAN Bus network diagrams
• Connector views
• Ground point diagrams

Serpentine Belt and Timing System Information

• Timing chain inspection procedures
• Timing chain replacement procedures
• Camshaft timing specifications
• Timing mark illustrations
• Accessory drive belt routing
• Drive belt inspection
• Timing component inspection

Torque Specifications

• Cylinder head bolt torque
• Main bearing cap torque
• Connecting rod bolt torque
• Crankshaft pulley torque
• Camshaft sprocket torque
• Flywheel torque
• Clutch assembly torque
• CVT component torque
• Wheel nut torque
• Brake caliper torque
• Suspension fastener torque
• Driveshaft fastener torque
• Differential fastener torque
• Engine mount torque
• Spark plug torque

Maintenance and Service Information

• Factory maintenance schedules
• Engine oil specifications
• Manual transmission oil specifications
• Xtronic CVT fluid specifications
• Transfer case fluid specifications where fitted
• Rear differential oil specifications where fitted
• Coolant specifications
• Brake fluid specifications
• Spark plug replacement intervals
• Air filter servicing
• Cabin air filter replacement
• Drive belt inspection
• Timing chain inspection
• Cooling system maintenance
• Brake inspection procedures
• Tyre rotation procedures
• Battery maintenance

Who Is This Manual For?

• New Zealand automotive workshops
• Independent repair garages
• Automotive technicians
• Auto electricians
• Diagnostic specialists
• Fleet maintenance teams
• DIY owners
• Automotive training institutions